Workshop Repair and Service Manuals GMC SIERRA
Articles

Powertrain

09-04-19-002B 4WD System Shift Performance in Cold Ambient Temperatures (Use Synthetic Fluid in Light Duty Front Axles with 8 25 Inch Ring Gears) - (Sep 14 2012) Axles      Subject: 4WD System Shift Performance in Cold Ambient Temperatures (Use Synthetic Fluid inLight Duty Front Axles with 8.25” Ring Gears) Models:  1999-2013 Chevrolet Silverado 1500 Series Models 1999-2013 GMC...
09-06-04-015B Information on Vehicles Sitting Outside on Dealer Lots for Extended Periods of Time with Hard Start or Crank No Start Condition - (Nov 4 2013) Driveline Control 4WD Driveline Control      Subject: Information on Vehicles Sitting Outside on Dealer Lots for Extended Periods of Timewith Hard Start or Crank/No Start Condition Models:  2009-2014 GM Cars and Trucks Attention:  The Information in this...
09-06-04-026G Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2) - (Mar 19 2013) - part 8      The Calibrations Group will also update the PQCor TAC case with the results of the Calibration Verification Request. Be prepared to provide all the usual documentation that is normally required whenrequesting an assembly...
09-06-04-026G Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2) - (Mar 19 2013) - part 7      procedure for All Service Agents for E-mailing .jpg or JPEG Files to the CalibrationGroup at — TACCVN@gmexpert.com in order to e-mail your findings to the Calibration Group, who will then documentyour information with the...
09-06-04-026G Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2) - (Mar 19 2013) - part 6      Refer to Section: 7. Creating a JPEG (.jpg) File From a GDS 2 Calibration HistoryScreen Shot Using Microsoft Paint Retain a copy of the printed screen shot with the repair order.7. Creating a JPEG (.jpg) File From a GDS 2...
09-06-04-026G Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2) - (Mar 19 2013) - part 5      Tech 2® Displaying All Zeroes for the Verification Numbers on the Vehicle Information- Calibration ID and Verification No. (Number/CVN) Screen Notice: Two examples of the Tech 2® Vehicle Information - (Engine) Calibration...
09-06-04-026G Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2) - (Mar 19 2013) - part 4      The Service Agent Service Department Personnel is REQUIRED TO E-MAIL TAC the digitalCalibration Verification photos from the Tech 2® screen or GDS 2 screen shot in .jpgor JPEG format only, to the following e-mail address:...
09-06-04-026G Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2) - (Mar 19 2013) - part 3      If a non-GM calibration is found and verification has taken place through GM, theremaining powertrain and driveline warranty may be blocked and notated in Global Warranty Management (GWM) and the dealership willbe notified....
09-06-04-026G Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2) - (Mar 19 2013) - part 2      Be advised that GM REQUIRES retrieving the Calibration Information and performingthe Calibration Verification Procedure as outlined in this Bulletin, whenever diagnosticsdetermine a hard part failure may have occurred on...
09-06-04-026G Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8 Gasoline Engines Using Tech 2 or Global Diagnostic System 2 (GDS 2) - (Mar 19 2013)      Subject: Identifying Non-GM (Aftermarket) Engine and Transmission Calibrations for V6 and V8Gasoline Engines Using Tech 2® or Global Diagnostic System 2 (GDS 2) Models:  2006-2014 GM Passenger Cars and Light Duty...
09-07-30-018D Warranty Administration - Change in Automatic Transmission Add Condition Documentation and Claim Submission - (May 10 2013) Automatic - part 2      Note:For reconditioning work beyond base repair, OLH must be documented by clock time whenreconditioning begins and is completed. OLH should not be used for work included inthe base repair time. Note:For steering wheel angle...
09-07-30-018D Warranty Administration - Change in Automatic Transmission Add Condition Documentation and Claim Submission - (May 10 2013) Automatic      Subject: Warranty Administration – Change in Automatic Transmission Add Condition Documentationand Claim Submission Models:  2014 and Prior GM Passenger Cars and Trucks Attention:  This bulletin applies to all...
09-08-57-002D General Water Leak Diagnostic Guide - (Feb 4 2013) Driveline Control 4WD Driveline Control - part 5      Theabove graphic shows two examples of seams missing sealer. (The position of seams 1and 2, in relationship to each other, is shown clearer in the graphic below). Correction Remove the left front fender from the vehicle....
09-08-57-002D General Water Leak Diagnostic Guide - (Feb 4 2013) Driveline Control 4WD Driveline Control - part 4      Cause Water may be entering the vehicle through the center high mounted stop lamp (CHSML)opening, and may leak down the B and/or C-pillars. Correction Lower the headliner and water test by running water onto the outer CHSML...
09-08-57-002D General Water Leak Diagnostic Guide - (Feb 4 2013) Driveline Control 4WD Driveline Control - part 3      Any water thatgets past the glass seal is routed through the drain tubes. The area marked (3) isthe sunroof mechanism track and no water should be in this area. If there is waterin area (3) it will leak out between the end cap...
09-08-57-002D General Water Leak Diagnostic Guide - (Feb 4 2013) Driveline Control 4WD Driveline Control - part 2      If not, a foam block canbe used to push the drain tube down to provide additional downward slope as shownabove. Condition 3 Water becomes trapped in the lower end of a rear sunroof drain tube and is not drainingproperly into...
09-08-57-002D General Water Leak Diagnostic Guide - (Feb 4 2013) Driveline Control 4WD Driveline Control      Subject: General Water Leak Diagnostic Guide Models:  2007-2013 Chevrolet Silverado 2007-2013 GMC Sierra Attention:  The intent of this bulletin is to provide diagnostic tips for some common areas thatmay...
10-00-89-005C Warranty Administration - Revised Wiring Repair Labor Operations and Required Additional Information - (May 7 2013) Driveline Control 4WD Driveline Control - part 2      This technician used the SI document shown below to locate a chafed wire causing aninterior lamp issue. The technician repaired a circuit just left of the steering column. When submitting the warranty transaction, the...
10-00-89-005C Warranty Administration - Revised Wiring Repair Labor Operations and Required Additional Information - (May 7 2013) Driveline Control 4WD Driveline Control      Subject: Warranty Administration – Revised Wiring Repair Labor Operations and Required AdditionalInformation Models:  2014 and Prior GM Passenger Cars and Light Duty Trucks     This bulletin is being...
10-00-89-006B Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only) - (Aug 27 2012) Driveline Control 4WD Driveline Control - part 3      Photo images - JPG format (For photo advice, please refer to the latest version CorporateBulletin Number 07-00-89-036)Audio files - WAV formatVideo files – the standard Movie or Video formats of most digital cameras are...
10-00-89-006B Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only) - (Aug 27 2012) Driveline Control 4WD Driveline Control - part 2      Completing the Enhanced PIR Form The Enhanced PIR form is located in the Service Workbench of GlobalConnect. The PartnerSecurity Coordinator for your dealership MUST enable this link so that each memberof the dealer service...
10-00-89-006B Information for Dealers on How to Submit a Product Information Report (PIR) (Canada Only) - (Aug 27 2012) Driveline Control 4WD Driveline Control      Subject: Information for Dealers on How to Submit a Product Information Report (PIR) (CanadaOnly) Models:  2013 and Prior GM Passenger Cars and Trucks Attention:  U.S. dealers should refer to the latest...
10-00-89-016A Correct Selection Of Labor Codes - (May 13 2013) Driveline Control 4WD Driveline Control      Subject: Correct Selection of Labor Codes Models:  2010-2014 GM Passenger Cars and Light Duty Trucks     This bulletin is being revised to include the 2012-2014 model years and update theLabor Operation...
10-07-30-001D Fluid Oil Leak During Cold Weather from Transmission Vent - (Feb 22 2013) Automatic Transmission Unit      Subject: Fluid/Oil Leak During Cold Weather from Transmission Vent Models:  2001-2013 Chevrolet Silverado 2500HD-3500HD Series 2001-2013 GMC Sierra 2500HD-3500HD Series Equipped with Allison® LCT 1000...