Workshop Repair and Service Manuals GMC SIERRA
Articles

Relay Replacement (Attached to Wire Harness) Relays

Rating:

Removal Procedure

Relay Replacement (Attached to Wire Harness) Relays

Locate the relay. Refer to theMaster Electrical Component Listto locate the relay in the vehicle.Remove any fasteners which hold the relay in place.Remove any connector position assurance (CPA) devices or secondary locks.

Note:Use care when removing a relay in a wiring harness when the relay is secured by fastenersor tape.

Separate the relay-(1) from the wire harness connector-(2).Installation Procedure

Relay Replacement (Attached to Wire Harness) Relays

Connect the relay-(1) to the wire harness connector-(2).Install any connector position assurance (CPA) devices or secondary locks.Install the relay using any fasteners or tape that originally held the relay in place.

Relay Rod Replacement (Dual Rear Wheels or Crew Cab With SRW) Relays     Special Tools J 24319-BSteering Linkage and Tie Rod Puller For equivalent regional tools, refer toSpecial Tools. Removal ProcedureRemove the engine shield, if equipped. Refer toEngine Shield Replacement.Remove the steering...
Drive Motor Battery Positive High Voltage Contactor Relay Replacement Relays     Drive Motor Battery Positive High Voltage Contactor Relay Replacement Callout Component Name Danger:Always perform the High Voltage Disabling procedure prior toservicing any High Voltage component or connection....
08-06-03-006B Engine Running with Key Off Continuous Run - Sensing and Diagnostic Module (SDM) No Communication Service Air Bag Light Illuminated DTCs B1440 P0381 or P0650 (Install Diode to Solenoid Relay) - (Aug 2 2012) Relays     Subject: Engine Running with Key Off, Continuous Run – Sensing Diagnostic Module (SDM), NoCommunication, Service Air Bag Light Illuminated, DTCs B1440, P0381 or P0650 (InstallDiode to Solenoid/Relay) Models:...
08-06-03-006B Engine Running with Key Off Continuous Run - Sensing and Diagnostic Module (SDM) No Communication Service Air Bag Light Illuminated DTCs B1440 P0381 or P0650 (Install Diode to Solenoid Relay) - (Aug 2 2012) Relays - part 2     Be sure to insulate the diode withheat shrink tubing before installing. Parts Information Part Number Description Qty 12112422 Diode 1 Warranty Information This repair will not be covered under warranty due to...
Relay Replacement (Attached to Wire Harness) Relays     Removal Procedure Locate the relay. Refer to theMaster Electrical Component Listto locate the relay in the vehicle.Remove any fasteners which hold the relay in place.Remove any connector position assurance (CPA) devices or...
Battery Positive Junction Block Cable Replacement (Glow Plug Module - Diesel) Junction Box     Battery Positive Junction Block Cable Replacement Callout Component Name Preliminary Procedures Disconnect the battery negative cable. Refer toBattery Negative Cable Disconnection and Connection. 1 Mega-Fuse...